Your wrecks seem insignificant - *SR-71 crash story*

[RedRocket1647545505]

Long read, but WELL worth it. These guys are badass.

 

 

"By Bill Weaver

 

Among professional aviators, there's a well-worn saying: Flying is

simply hours of boredom punctuated by moments of stark terror. And

yet, I don't recall too many periods of boredom during my 30-year

career with Lockheed, most of which was spent as a test pilot.

 

By far, the most memorable flight occurred on Jan. 25, 1966. Jim

Zwayer, a Lockheed flight test reconnaissance and navigation systems

specialist, and I were evaluating those systems on an SR-71 Blackbird

test from Edwards AFB, Calif. We also were investigating procedures

designed to reduce trim drag and improve high-Mach cruise

performance. The latter involved flying with the center-of-gravity

(CG) located further aft than normal, which reduced the Blackbird's

longitudinal stability.

 

We took off from Edwards at 11:20 a.m. and completed the mission's

first leg without incident. After refueling from a KC-135 tanker, we

turned eastbound, accelerated to a Mach 3.2-cruise speed and climbed

to 78,000 ft., our initial cruise-climb altitude.

 

Several minutes into cruise, the right engine inlet's automatic

control system malfunctioned, requiring a switch to manual control.

The SR-71's inlet configuration was automatically adjusted during

supersonic flight to decelerate air flow in the duct, slowing it to

subsonic speed before reaching the engine's face. This was

accomplished by the inlet's center-body spike translating aft, and by

modulating the inlet's forward bypass doors. Normally, these actions

were scheduled automatically as a function of Mach number,

positioning the normal shock wave (where air flow becomes subsonic)

inside the inlet to ensure optimum engine performance.

 

Without proper scheduling, disturbances inside the inlet could result

in the shock wave being expelled forward--a phenomenon known as an

"inlet unstart." That causes an instantaneous loss of engine thrust,

explosive banging noises and violent yawing of the aircraft--like

being in a train wreck. Unstarts were not uncommon at that time in

the SR-71's development, but a properly functioning system would

recapture the shock wave and restore normal operation.

 

 

On the planned test profile, we entered a programmed 35-deg. bank

turn to the right. An immediate unstart occurred on the right engine,

forcing the aircraft to roll further right and start to pitch up. I

jammed the control stick as far left and forward as it would go. No

response. I instantly knew we were in for a wild ride.

 

I attempted to tell Jim what was happening and to stay with the

airplane until we reached a lower speed and altitude. I didn't think

the chances of surviving an ejection at Mach 3.18 and 78,800 ft. were

very good. However, g-forces built up so rapidly that my words came

out garbled and unintelligible, as confirmed later by the cockpit

voice recorder.

 

The cumulative effects of system malfunctions, reduced longitudinal

stability, increased angle-of-attack in the turn, supersonic speed,

high altitude and other factors imposed forces on the airframe that

exceeded flight control authority and the Stability Augmentation

System's ability to restore control.

 

Everything seemed to unfold in slow motion. I learned later the time

from event onset to catastrophic departure from controlled flight was

only 2-3 sec. Still trying to communicate with Jim, I blacked out,

succumbing to extremely high g-forces. The SR-71 then literally

disintegrated around us.

 

From that point, I was just along for the ride.

 

My next recollection was a hazy thought that I was having a bad

dream. Maybe I'll wake up and get out of this mess, I mused.

Gradually regaining consciousness, I realized this was no dream; it

had really happened. That also was disturbing, because I could not

have survived what had just happened. Therefore, I must be dead.

Since I didn't feel bad--just a detached sense of euphoria--I decided

being dead wasn't so bad after all.

 

AS FULL AWARENESS took hold, I realized I was not dead, but had

somehow separated from the airplane. I had no idea how this could

have happened; I hadn't initiated an ejection. The sound of rushing

air and what sounded like straps flapping in the wind confirmed I was

falling, but I couldn't see anything. My pressure suit's face plate

had frozen over and I was staring at a layer of ice.

 

The pressure suit was inflated, so I knew an emergency oxygen

cylinder in the seat kit attached to my parachute harness was

functioning. It not only supplied breathing oxygen, but also

pressurized the suit, preventing my blood from boiling at extremely

high altitudes. I didn't appreciate it at the time, but the suit's

pressurization had also provided physical protection from intense

buffeting and g-forces. That inflated suit had become my own escape

capsule.

 

My next concern was about stability and tumbling. Air density at high

altitude is insufficient to resist a body's tumbling motions, and

centrifugal forces high enough to cause physical injury could develop

quickly. For that reason, the SR-71's parachute system was designed

to automatically deploy a small-diameter stabilizing chute shortly

after ejection and seat separation. Since I had not intentionally

activated the ejection system--and assuming all automatic functions

depended on a proper ejection sequence--it occurred to me the

stabilizing chute may not have deployed.

 

However, I quickly determined I was falling vertically and not

tumbling. The little chute must have deployed and was doing its job.

Next concern: the main parachute, which was designed to open

automatically at 15,000 ft. Again, I had no assurance the

automatic-opening function would work.

 

I couldn't ascertain my altitude because I still couldn't see through

the iced-up face plate. There was no way to know how long I had been

blacked-out, or how far I had fallen. I felt for the

manual-activation D-ring on my chute harness, but with the suit

inflated and my hands numbed by cold, I couldn't locate it. I decided

I'd better open the face plate, try to estimate my height above the

ground, then locate that "D" ring. Just as I reached for the face

plate, I felt the reassuring sudden deceleration of main-chute

deployment.

 

I raised the frozen face plate and discovered its uplatch was broken.

Using one hand to hold that plate up, I saw I was descending through

a clear, winter sky with unlimited visibility. I was greatly relieved

to see Jim's parachute coming down about a quarter of a mile away. I

didn't think either of us could have survived the aircraft's breakup,

so seeing Jim had also escaped lifted my spirits incredibly.

 

I could also see burning wreckage on the ground a few miles from

where we would land. The terrain didn't look at all inviting--a

desolate, high plateau dotted with patches of snow and no signs of

habitation.

 

I tried to rotate the parachute and look in other directions. But

with one hand devoted to keeping the face plate up and both hands

numb from high-altitude, subfreezing temperatures, I couldn't

manipulate the risers enough to turn. Before the breakup, we'd

started a turn in the New Mexico-Colorado-Oklahoma-Texas border

region. The SR-71 had a turning radius of about 100 mi. at that speed

and altitude, so I wasn't even sure what state we were going to land

in. But, because it was about 3:00 p.m., I was certain we would be

spending the night out here.

 

At about 300 ft. above the ground, I yanked the seat kit's release

handle and made sure it was still tied to me by a long lanyard.

Releasing the hea vy kit ensured I wouldn't land with it attached to

my derriere, which could break a leg or cause other injuries. I then

tried to recall what survival items were in that kit, as well as

techniques I had been taught in survival training.

 

Looking down, I was startled to see a fairly large animal--perhaps an

antelope--directly under me. Evidently, it was just as startled as I

was because it literally took off in a cloud of dust.

 

My first-ever parachute landing was pretty smooth. I landed on fairly

soft ground, managing to avoid rocks, cacti and antelopes. My chute

was still billowing in the wind, though. I struggled to collapse it

with one hand, holding the still-frozen face plate up with the other.

 

"Can I help you?" a voice said.

 

Was I hearing things? I must be hallucinating. Then I looked up and

saw a guy walking toward me, wearing a cowboy hat. A helicopter was

idling a short distance behind him. If I had been at Edwards and told

the search-and-rescue unit that I was going to bail out over the

Rogers Dry Lake at a particular time of day, a crew couldn't have

gotten to me as fast as that cowboy-pilot had.

 

The gentleman was Albert Mitchell, Jr., owner of a huge cattle ranch

in northeastern New Mexico. I had landed about 1.5 mi. from his ranch

house--and from a hangar for his two-place Hughes helicopter. Amazed

to see him, I replied I was having a little trouble with my chute. He

walked over and collapsed the canopy, anchoring it with several

rocks. He had seen Jim and me floating down and had radioed the New

Mexico Highway Patrol, the Air Force and the nearest hospital.

 

Extracting myself from the parachute harness, I discovered the source

of those flapping-strap noises heard on the way down. My seat belt

and shoulder harness were still draped around me, attached and

latched. The lap belt had been shredded on each side of my hips,

where the straps had fed through knurled adjustment rollers. The

shoulder harness had shredded in a similar manner across my back. The

ejection seat had never left the airplane; I had been ripped out of

it by the extreme forces, seat belt and shoulder harness still

fastened.

 

I also noted that one of the two lines that supplied oxygen to my

pressure suit had come loose, and the other was barely hanging on. If

that second line had become detached at high altitude, the deflated

pressure suit wouldn't have provided any protection. I knew an oxygen

supply was critical for breathing and suit-pressurization, but didn't

appreciate how much physical protection an inflated pressure suit

could provide. That the suit could withstand forces sufficient to

disintegrate an airplane and shred heavy nylon seat belts, yet leave

me with only a few bruises and minor whiplash was impressive. I truly

appreciated having my own little escape capsule.

 

After helping me with the chute, Mitchell said he'd check on Jim. He

climbed into his helicopter, flew a short distance away and returned

about 10 min. later with devastating news: Jim was dead. Apparently,

he had suffered a broken neck during the aircraft's disintegration

and was killed instantly. Mitchell said his ranch foreman would soon

arrive to watch over Jim's body until the authorities arrived.

 

I asked to see Jim and, after verifying there was nothing more that

could be done, agreed to let Mitchell fly me to the Tucumcari

hospital, about 60 mi. to the south.

 

I have vivid memories of that helicopter flight, as well. I didn't

know much about rotorcraft, but I knew a lot about "red lines," and

Mitchell kept the airspeed at or above red line all the way. The

little helicopter vibrated and shook a lot more than I thought it

should have. I tried to reassure the cowboy-pilot I was feeling OK;

there was no need to rush. But since he'd notified the hospital staff

that we were inbound, he insisted we get there as soon as possible. I

couldn't help but think how ironic it would be to have survived one

disaster only to be done in by the helicopter that had come to my

rescue.

 

However, we made it to the hospital safely--and quickly. Soon, I was

able to contact Lockheed's flight test office at Edwards. The test

team there had been notified initially about the loss of radio and

radar contact, then told the aircraft had been lost. They also knew

what our flight conditions had been at the time, and assumed no one

could have survived. I briefly explained what had happened,

describing in fairly accurate detail the flight conditions prior to

breakup.

 

The next day, our flight profile was duplicated on the SR-71 flight

simulator at Beale AFB, Calif. The outcome was identical. Steps were

immediately taken to prevent a recurrence of our accident. Testing at

a CG aft of normal limits was discontinued, and trim-drag issues were

subsequently resolved via aerodynamic means. The inlet control system

was continuously improved and, with subsequent development of the

Digital Automatic Flight and Inlet Control System, inlet unstarts

became rare.

 

Investigation of our accident revealed that the nose section of the

aircraft had broken off aft of the rear cockpit and crashed about 10

mi. from the main wreckage. Parts were scattered over an area

approximately 15 mi. long and 10 mi. wide. Extremely high air loads

and g-forces, both positive and negative, had literally ripped Jim

and me from the airplane. Unbelievably good luck is the only

explanation for my escaping relatively unscathed from that

disintegrating aircraft

 

Two weeks after the accident, I was back in an SR-71, flying the

first sortie on a brand-new bird at Lockheed's Palmdale, Calif.,

assembly and test facility. It was my first flight since the

accident, so a flight test engineer in the back seat was probably a

little apprehensive about my state of mind and confidence. As we

roared down the runway and lifted off, I heard an anxious voice over

the intercom.

 

"Bill! Bill! Are you there?"

 

"Yeah, George. What's the matter?"

 

"Thank God! I thought you might have left." The rear cockpit of the

SR-71 has no forward visibility--only a small window on each

side--and George couldn't see me. A big red light on the

master-warning panel in the rear cockpit had illuminated just as we

rotated, stating, "Pilot Ejected." Fortunately, the cause was a

misadjusted microswitch, not my departure.

 

Bill Weaver flight tested all models of the Mach-2 F-104 Starfighter

and the entire family of Mach 3+ Blackbirds--the A-12, YF-12 and

SR-71. He subsequently was assigned to Lockheed's L-1011 project as

an engineering test pilot, became the company's chief pilot and

retired as Division Manager of Commercial Flying Operations. He still

flies Orbital Sciences Corp.'s L-1011, which has been modified to

carry a Pegasus satellite-launch vehicle (AW&ST Aug. 25, 2003, p.

56). An FAA Designated Engineering Representative Flight Test Pilot,

he's also involved in various aircraft-modification projects,

conducting certification flight tests."

 

 

 

Top that!

[Sam1647545489]

Cliffs????

[Science Abuse]

I tied both my shoes today.

 

From SR-71s to a L-1011? Had to be a hell of a shift.

 

Cliffs:

I went to public school and took English class in almost every grade. I learned to read there, and applied that to this story about a guy wrecking a plane at mach3+.

[SpaceGhost]

Good story, Sam you are lazy.

[SilverEvo8owner]

Cliffs

 

SR-71 flying at mach 3 has an engine inlet fail, causing his plane to yaw severely and approach critical angle of attack for the plane's airframe design. Plane breaks apart and he is torn from his ejection seat and blacks out at 76,000 feet. Regains conciousness while free falling in his space suit. Falls to 15,000 feet when his chute deploys and land in a cow field. Some cowboy picks him up in a POS helocopter and flys him to the airport but escapes with minor injuries.

 

Copilot died.

[thorne]

go cliffs wish i would have known they were there before my lunch got cold

[Mojoe]

It's a good read. I read it last night. Requires some knowledge of flying that I don't have. Very accomplished pilot made it through a crazy situation.